how do i stop my suzuki liana boiling over?

Hi friends. if the liana engine was overheated very extremly , which make head gas kit ( a seal between head and assembly ) is burned or damaged. replace it and make the face of head if needed. your over haeting will be solved perminantly until the next extreme heatup.

Zeeshan Javed
September 2012

Hi

Could the original poster confirm if Dann's advice worked. I am facing a similar problem on my Suzuki Liana where the coolant boils over and fills and eventually overflows from expansion tank.

autocrazy
May 2012

it over heats wen air con is turned on put a new radiator in it the heater hose r diconected

matthew
February 2012

went for a 300 mile motorway drive yesterday and dashboard heater gauge did not show engine overheating,however when i stopped for break at service station there was water running from underneath car..looked under bonnet but no signs of leakage ????? will try the pouring water into hose thing and see if it repairs the problem.thanks Dann

steve spencer
September 2007

Locate the heater hoses, there will be two about 3/4in dia. They pass through the bulkhead behind the engine. With the engine off and cool disconnect the uppermost hose at the engine end. Hold the end of the hose up as high as possible and pour water into it. Keep pouring until all air bubbles stop coming out then quickly reconnect the hose to the engine. Run the engine with the heater controls on full hot. Eventually hot air should come out of the heater which means everything is ok. Finally check for leaks and top up coolant level when the engine has been off for ten minutes.

Dann
September 2007