Hi
my daily as a cold starting problem , when i turn the key engine turns over for about 5mins before it starts, now after 2mins white smoke apirs then it starts to try to fire up 3 mins later it starts .
so far ive replaced all injectors , fuel regulator, fuel filter, preheated plug, timing belt, oil change, and checked all fuses and relays but still have this problem . milage is 088568
can any one advise me
replace the battery, battery should be 800cca
have battery checked, my customer is happy now.
NAIDER TALEB
March 2011
It is known for these vans to drop back diesel on occasion, A common place is the pipes or quick release pipe fittings at the filter housing and high pressure pump. Put constant power to low pressure pump and listen for air. Hope this helps
Jimmy Diesel Junior
October 2010
I have a 56 plate iveco with 80k on the clock and mine is the same!!! is it a fault of the iveco model? can it be cured? HELP!!
chris
December 2009
Hi keith, did you have any luck fixing your iveco? i have a 2002 35s11 75k on the clock with EXACTLY the same problem . My first thought was glow plugs, untill i found out they dont have any! and the chap at iveco said the cold start valve doesn't even start working untill about -15 degrees so it couldn't be that either.
It would seem there are a lot of people with the same or similar problems on forums like this but nobody has a definitive answer.
Adam
June 2009
Hi Keith... check to see if the pre heaters are really pulling current... should be about 50 amps at switch on... if that does not help let your local garage do a compression check on all the cylinders, although they should be ok considering the low milage.. success... Bill.
Bill Owens
May 2009
thanks nike ive had that checked out and its o.k
still have the problem.
keith
April 2009
It could be a faulty timing solenoid that feeds the fuel to the injectors. Good luck.
howtomendit.com for free repair help, information and advice.
Try fixfault.com to fix vans.