Recent: Lg vcr?

Mend > Vans

Mend Citroën Berlingo 2.0 HDI System Air Running

berlingo 2.0 HDI van fuel system?

I have air in the fuel system and the van cuts out when running at speed. I can see lots of air coming in through the fuel pipes to the filter. I have replaced all the pipes up to the tank from the filter, bulb primer and all, could it be a problem inside the tank?
HELP!!!!!

Steve G
November 2008
CitroënCitroën Berlingo 2.0 HDIVehicles, VansSystem Air Running
same problem with my dads berlingo 1.9d,its the fuel pick up in tank the filter gauze which is part of gauge sender unit,had a slimmy goo over it ,cleaning it out would sort it though we replaced it now it has much more power and problem sorted.

leigh ,mister mechanic
July 2011
I have a similar problem on my 1.9 diesel multispace. It cuts out when fuel guage reads a quarter full. Have pumped out three gallons of diesel all of which have air in the pipe.

Ray
December 2008
Sounds very like the high pressure pump in the tank steve these are known for failure and sorry to say are costly about £300 fitted if my memory serves me right you will know for sure if you take out the fuel filter the sediment chamber atthe bottom of the filter housing will have copper or silver coloured metal shavings in it

kevin
November 2008
i used apetrol can disconnect pipes at tank may have to extend them with hose[i used heater hose]stick two pipes in container.give it a go.nowt to lose but yor time.worked on my golf

glen
November 2008

Related Questions ...

Mend diesel glow plugs cold start
1

another berlingo cold starting problem!?

my 2004 1.9 started this problem on a trip to the pyrenees in sept, and has got worse,i have just fitted new g... [Read more]
Mend heat car heater
1

Megane 1.5 DCi on 52 Plate - No heat from in car heater?

Getting no heat from the in car heater. Have checked coolant and is set to good levels, have bled the coolant ... [Read more]
Mend stop am radio
1

How can I stop AM radio interference?

We have a Direct Ventilation System with a small high volume 240v single ph variable speed drive in the ceilin... [Read more]
Mend power system running start
2

Ryobi RLT30CES power unit for expand-it system?

Was running beautifully then refused to start. Have replaced plug, cleaned air filter, won't even fire
Mend rid air system
2

How can I get rid of trapped air in central heating system?

After replacing the small rubber seal on the shaft of the hydraulic actuator in my BIASI 24S Combi boiler, the... [Read more]
Mend renault megane sport
1

Renault Megane Sport 225 dilemma?

Hi, I have a 2004 Renault Sport Megane 225 Phase II. No mods, K&N short ram replacing the standard air box set... [Read more]
Mend combi boiler heating pressure gauge
1

pressure gauge on combi boiler?

I have a Ravenheat RSF 820/20T fanned combi the pressure gauge on it shows an increase in pressure above the i... [Read more]
Mend ford mondeo 2ltr
1

ford mondeo 08 diesel 2ltr injector leak off pipes?

2 weeks ago smell of diesel in my mondeo and the garage who repaired it said it was due to leak off pipes leak... [Read more]
Mend boiler hot water good
1

alpha boiler - hot water ok but only slight central heating ?????????

boiler is lighting and giving good hot water but the central heating is just lookwarm even after 3 or 4 hours ... [Read more]
Mend low engine light help
1

Rover 25 Low Engine Coolant light staying on ( we need your help)?

I have recently purchased a 25 for my wife its the GLI model on a 55 plate its had strange electrical faults s... [Read more]
Mend heating radiators system
3

heating, Oil boiler not running?

Having just drained my heating system to replace a number of failing radiators,I have re-filled the system but... [Read more]
Mend worcester boiler fitted
2

Banging Pipes - Hot water only?

We have a worcester boiler (in our new house) which was fitted 9 yrs ago - for some reason it has been left as... [Read more]
Mend boiler central heating blockage
2

Help with Worcester greenstar ri?

Hi, drained a central heating vented system today to fit a new rad valve, turned the cold water back on and re... [Read more]
Mend central heating heat exchanger pressure
2

Glowworm 24CI Hot water problem?

MY system's central heating seems fine but it's having problems with the hot water. The system fires up and s... [Read more]
Mend cooling system overheating radiator
1

High Temperature on 1993 Clio?

Hi, I have a 1993 1.4 Clio, the temperature gauge keeps going sky high, I've been told it's an air lock. I've ... [Read more]
Mend berlingo van wheel

Braking fault?
Mend settings head bolts

have you got torque settings for berlingo 1999 1.8 petrol?
Mend berlingo electrics citroën

No accessory mode electrics unless engine running?
Mend citreon berlingo van

citreon berlingo 2.0 hdi van?
Mend battery alternator car

Battery drain (or alternator or electrics?) on Citroen Berlingo 2008?
Mend start months started

citreon dispatch wont start?
Mend berlingo timing belt

does the berlingo bend valves when the timing belt snaps?
Mend Vehicles, Vans

how to fix speedo on 2004 berlingo?
Mend central locking citroen

central door locking on Citroen Dispatch van not working properly?
Mend heater light three

Citreon berlingo 1.9 diesal ?
Mend starter motor citroen

Wiring to relay between fuse and starter motor?
Mend door lock issue

Citroen dispatch rear door lock issue?

How to mend ...

Find out how to mend just about anything howtomendit.com for free repair help, information and advice.
Mend Vans ...

Other models...

Citroen 600DCitroen BelingoCitroen BerlingoCitroën Berlingo 1.6 HDICitroën Berlingo 1.9Citroen Berlingo 1.9 dieselCitroen Berlingo 1.9DCitroën Berlingo MultispaceCitroen C15Citroen DespatchCitroen DispatchCitroen Dispatch 1.9DCitroen Dispatch HdiCitroen PicassoCitroen Relay HDICitroen SaxoCitroen Saxo 1.1Citroen XantiaCitroen XsaraCitroen Xsara Picasso

Related Categories

Mend Caravans/Motorhomes
Caravans/Motorhomes
Mend Cars
Cars
Mend Lorries/Trucks
Lorries/Trucks
Mend Mobile Homes
Mobile Homes
Mend Motorcycles
Motorcycles
Mend Tractors
Tractors
Mend Trailers
Trailers

Topic

Citroën Berlingo 2.0 HDI - Fuel System Issue