Recent: Will I need to replace my garden tap?

Mend > Vans

Mend Ford Transit 190 LWB Diesel Engine Injector Pump

Injector pump belt?

My vehicle is a Transit 190 LWB panel van. 2496 cc diesel 1998. The engine recently died on me in Spain and the problem appears to be that the injector pump pulley at the front is not turning. I ascertained this by removing the top bolts of the drive belt cover and prising it forward to see the gear wheel on the front of the pump. The drive belt is not broken and although the engine turns over normally, the drive belt does,nt move. The vehicle is very low mileage [Just over 100K]
What could the problem be and how can I fix it?

Tom Wadham
August 2009
FordFord Transit 190 LWBVehicles, VansDiesel Engine Injector Pump
teeth will be missing on section of belt ,you will need to remove it to check-then you will need to re-time engine fit new belt, remove rocker cover and straighten the push rods that are bent [or fit new] ,i think there is a modified auto adjusting idler that you will be better off fitting.

k
August 2009

Automatic Answer

We may have found other answers which could help you.

Click here for Diesel Engine Injector Pump

Related Questions ...

Mend fuel starts runs diesel
3

Fuel leak on iveco daily 99. 2.8t?

My van starts and runs but have a leak on diesel system, when reving engine its spurting lots out from around ... [Read more]
Mend 2008 help engine
4

2008 trafic 115dci?

help needed please, took van for engine service before a planned holiday After an engine service oil, oil filt... [Read more]
Mend turbo problem engine
3

vj transit turbo diesel?

i have a major problem with a 2006 model transit, as i am driving the engine cuts off or lack of power especi... [Read more]
Mend transit diesel injector
1

ford transit 2.4 turbo diesel rear drive non start?

ford transit 2006 2.4 turbo diesel is cranking but not firing up. There is diesel in the tank but no diesel is... [Read more]
Mend diesel turbo injector pump
18

04 Ford Transit 2.4 350T diesel power loss?

New engine (Long block)12 months ago, went fine for 9 months then started surging (small) at 2700 RPM with po... [Read more]
Mend diesel engine injector
1

injector pipes?

diesel injector pipes keep breaking the pump is not lose the clamps are on. should the bottom water hose be ... [Read more]
Mend diesel fuel pump engine
2

how can i fix my fuel problem. 1993 ford transit 2.5 diesel?

I woz driving home then my van started to lose power and the revs died off like it ran out of diesel.(but i ha... [Read more]
Mend pump fuel model
2

how can i fix injector pump?

leaking diesel fuel from injector pump engine side 98 model 2.5 litre
Mend diesel injector pump transit
2

whats wrong with my transit van diesel engine ?

my 2.5 transit diesel, non turbo. 1996 ticks over but won't rev. started doing this all of a sudden. no warnin... [Read more]
Mend diesel engine transit
1

how can i find timing on my Ford Diesel?

How do i find Crankshaft/Camshaft/Injector pump timing on Ford Transit 2.5 Litre Diesel engine 1989??? HELP!!!
Mend rev stuck ford

my speedometer & rev counter have stuck on my 2007 ford tranit?
Mend Ford Transit Side Lights Fuse

Ford transit side lights?
Mend ford transit gearbox

Ford transit 56?
Mend ford transit motorhome

van won't start?
Mend fluid pedal foot

what needs fixing on my transit connect ?
Mend ford transit derestrict

How can I mend 2001 ford transit?
Mend Ford Transit Diesel Blue Smoke

blowing blue smoke?
Mend belt drive ford

Temporary hunting I geta new belt?
Mend ford remove speed

Ford courier?
Mend ford transit minibus

how can i fix?
Mend ford transit van

Ford transit van?
Mend Vehicles, Vans

how can i fix transit t350 gear selecter replace?

How to mend ...

Find out how to mend just about anything howtomendit.com for free repair help, information and advice.
Mend Vans ...

Other models...

Ford 06 TransitFord 2002 TransitFord ConnectFord Fiesta CourierFord MK7Ford TourneoFord Transit 1995Ford Transit 2.4Ford Transit 2.4 TDFord Transit 2.5 DiFord Transit 2001Ford Transit 2002Ford Transit 260Ford Transit 260 SWBFord Transit 300Ford Transit 80Ford Transit 80 SWBFord Transit MK6Ford Transit T260Ford Transit Tourneo

Related Categories

Mend Caravans/Motorhomes
Caravans/Motorhomes
Mend Cars
Cars
Mend Lorries/Trucks
Lorries/Trucks
Mend Mobile Homes
Mobile Homes
Mend Motorcycles
Motorcycles
Mend Tractors
Tractors
Mend Trailers
Trailers

Topic

Ford Transit 190 LWB - Injector Pump Belt Issue