fuel fault nissan cabstar?

Are you guys talking about the fuel banjo with the stop solenoid at the rear of the pump, or the banjo on the end of the fuel line that goes to the front right hand side ( between the pump and the engine block?

Island Dave
March 2016

oh and have replcaed all filters dont know how many times it runs fine then starts loss of power and smokes like hell fuel tank has been taken off and cleaned out, but this still keeps happening some one please help dont know what else to do with this problem

john brown
January 2015

we have nissan cabstar yr 2001 and keep having this same fault occuring is it a common problem with this vehicle? its costing a fortune at the garage to keep having this gauze thing blow out, priced up a new fuel pump and it was nissan only and was £2000. it runs fine for a while and then suddenly goes it cant be trusted to go far. the man who took the guaze out and chucked it away did it still go alright or did it knacker something else like the injectors? need some help this vehicle has only got 56,000 on the clock and is brilliant otherwise

john brown
January 2015

As if by magic.................
had same problem on cabstar e90, blue/white smoke, spluttering on revving up. Changed fuel filter without sucessful cure, removed gauze in pump and it was clogged.......cleaned it out and replaced it.....hey presto, perfect. Thanks for advice by all previous

des
November 2012

I had the same problem, lots of white/blue smoke and a misfire at half revs plus. The problem was indeed the small gauze filter under the main fuel inlet pipe, this is found on the top of the fuel pump at the the cooling fan end of the engine. You need to remove the drivers seat, (just two nuts under the drivers seat) then move the gear lever and cover to one side (no need to disconnect cables) and remove the engine cover plate, then move the power steering tank out of the way (again, no need to disconnect it but the front bolt is a real fiddle!) clean arround the banjo bolt before removing it. Hook the visible spring out with a hook made of wire and the tiny gauze filter also. Blow all the rubbish out of the filter and re-install (it's there to protect your fuel pump!)

Hey presto no more smoke, and loads of power!

Gaz, I'm very grateful for the advise.

JON WILSON
March 2012

sounds just like the problem i've got, however was your engine management on as mine seems to be on and off randomly??

Colin T
February 2012

l just replaced the fuel filter and has cured the problem, l had same symptoms with my cabstar.

roy
October 2010

i had a y reg cabstar the other day smoking like mad when reved up, on the top of the main pump near to the front take the bandjo bolt out of the main fuel feed pipe move the pipe to the side there is a spring inside the pump pull it out, then with a thin welding rod bend put a small hook on the end and have a poke around in the hole you will pull a very small fillter out throw it as far as you can replace the pipe and bandjo and presto fault sorted.

Daz,a
September 2010

Hi there mate had same problem till other day. take the stop solinid of the fuel pump. under that is a spring carefully thake that out. look right in bottom of hole it looks like a tiny copper ring. ai used a tiny bit of wire eith a u on the bottom and hook it out. It s a tiny gauze filter which will be full of crap blow out put all back together sorted . Be very suppersided if its not this mine was.

bezisbird.
June 2010

hi gaz, I have exacly the same problem ive had it for months now still unsolved. If you find the problem will you please let me know and i will do the same, regards Colin

Colin Atkins
April 2010