Ford Mondeo diesel keeps revving up by itself?

does any one no how to take the throttle sensor off a w reg ford fiesta 1.8td? because it keeps over revving and been told to take it off and spay with wd40?

wayne
May 2013

hi i have the same problem in my 96 td mondeo i have removed the hose from the regulater and desil is in there is this an easy fix or a big job

deebucko000
May 2012

sorry guys keyboard is bleeding useless Head Basket?? I meant head Gasket... duuuuuu

John Ford
March 2011

Mike B in answer to this you are not correct, Bluish smoke is usually associated to burning of Oil. Tha meaning oil entering into the fule and air mixture and being burnt in the combustion chamber. White smoke is associated to water in the oil and a dead give away to head basket problem is low compression and the water in the expansion tank appearing to be grey or the oil itself being grey. As for the the revving probs i also have this after changing the pipe that runs from the front to the side of the Turbo charger on the manifold.

John Ford
March 2011

Firstly many thanks to all the contributors on this site.

I had this problem with a 1.8 Mondeo turbo diesel - 1998 R reg, and it is now fixed!

I tried disconnecting the ECU, and inspecting the injector spill off pipes (suggestions from anthony and jessiejames). However, what fixed it was basically the reply from john (oct 2008) so thanks very much.
I suggest that you take the charge air cooler off and if there is any diesel fuel in that, it’s a good bet that the diaphragm has gone and the diesel is being sucked up the vacuum tube. (Anything with the CAV Roto Diesel pump may have this).

TheMechanic
October 2010

Thanks Antony.
I just sorted out the same prob on my Transit thanks to you. Tiny leak where the pipe goes back into the pump.

frenchfarmer
April 2010

Hello, amazing i had exactly the same problem on my p reg 1.8TD mondeo. I was given loads of advice about faulty pumps, lamda sensors etc, then i went to a grizzly old backstreet mechanic who told me to check the injector spill off pipes ( three rubber pipes that connect each injector in line to a common return) they were rotten and leaking! I got a set of replacement pipes from Mill autos for about £3. It has completely fixed it.
Apparently because they were leaking air was also leaking in and causing the problem.
Have a quick look while the engine is running.
Good luck

anthony
May 2009

I had a close look at the injector pump and if you look at it from the front of the car just right of centre you will see a small round bit sticking out with a metal cover over it, prise this off and undo the three torx screws holding the top on ( make a note of the spring !! ). In there you will see the diaphram, i was lucky enough to be able to take one off a car i am parting out that i knew was good. Since i swapped it, no problems ... so far. The part can't be more than a few quid and i would guess any diesel pump specialist could get one

john
October 2008

Can you tell me what actually cured this problem ? and if it is the fuel idle regulator , where is it and what does it look like ?
Thanks

johnc
October 2008

if you remove the battery negative then reconnect it then engine at fast idle for ten minutes it will resest the ecu as ford self learn

jessejames
July 2008

hi my mondeo has the same problem. anyone know what the fix was?

bob
June 2008

Hi, had this problem with mine. The bladder on the fuel idle regulator is shot. So when you idle fuel builds up and the excess releases on a gear change, usually from idle to 1st. I had this replaces and problem solved.

MikeB
May 2008

hi dale,

we shall not talk about blueish smoke since that usually indicates water getting into your oil or a head gasket problem to you or me!
the problem with the reving is usually the computer in your car, it tells the automatic choke to rev the car to keep the engine ticking over basically its had a fright one day and it revs now to stop the engine from stalling when ticking over.
best way to sort it is take your car for a diagnostics check (40quid) and these guys will reset your cars computer back to factory settings.... reving will stop

hope this helps

kevin docherty
May 2008