Hi there, I have just bought a 2002 Fiat Scudo 1.9 EL van. Unfortunately, the heater is'nt working. It is the non a/c version. Checked fuses-all fine. I removed the fan and linked it to a 12v battery, and it worked fine. So I presumed it must be the slider switch, so I got another, put it in to no avail. Anyone got any other ideas as to what it could be?
Does anyone know why rear heaters are not working the fan is working but no hot air
Brendan
September 2014
I have just fitted a replacement heater fan motor to my van. But the terminals only have 3 pins, the original has 4!
I know only 3 wires are used but in which order do they need to be?
I know the small green wire is in the middle but i don't know about the other 2
Any body help
fridgyman
June 2013
Similar issue, but I know its the actual control slider that is faulty, I tried a replacement second hand one but that had the same problem. Have rigged it up now so it runs off a switch at %50 all the time, was thinking of just wiring in a seperate resistor slider (potentiometer basically) on the control wire, however Im not sure what resistance range it should be, 10kohm, 50kohm? Any ideas? Can get them on ebay for about a fiver
Andrew
February 2013
deep under the pass footwell you'll see a brown connector that burns out...this will be your problem i bet as its a common fault
Stuart G
January 2013
My scudo 1.9el has been idle for a wee while..now got it roadworthy but the cabin heater/fan isnt working..help!its 1degree brrrrrr
brian
October 2012
Hi Ive just bought a 2.0JTD, guess what, heater not working. Ive checked with the volt meter and it all seems dead, checked the fuse and it looks good. Is there a relay for the heater fan and if so where is it. Mind you the problem is filling me full of hot air so maybe a heater is not needed :)
Ray
April 2011
hi, i have the same problem, the fan came back on two weeks ago after being broken for 8 months and has now gone off again. how do i get to the heater motor and the bushes to see if that is the problem, any photo's would be a great help, thanks,
you can mail me at Ianbidwell'at'gmail.com.
thanks again
ian
November 2010
do away with all the connectors from the slider to the fan. this worked for me
ginnerben
October 2010
Sounds like the heater motor brushes and needing replaced. They can be bought on ebay for £12.50
Does the heater have a mind of its own? Does it sometimes just come on if your driving along? Has it been working intermittantly? If any of these are the case then it sounds like the brushes.
baz
January 2010
hi same happend to mine brought a sec hand motor from scrapy 35 quid works fine now
bim
December 2009
you can bypass the resisters and put feed direct to the motor but then the fan is on full at all times
van man 2000uk
November 2008
where are capacitors located?........mine seem to be covered in resin?? how do you access them?
thanks nick
nick
October 2008
Hi, I have the same problem. I cannot see the capacitor that Dave mentioned, just a purpose built heat sink that would not be bought elsewhere.
Can anyone else help?
Regards
Alan
October 2008
hi gary there is a capacitor set inside the blower fan itself which is situated underneath the fuse box in the passenger footwell. It will cost under a pound for the resistor/capacitors from maplins if you can solder new ones to replace the old ones or get someone who can solder electronic its a simple job but very common problem. fiat etc just replace the whole unit at over £250.. dave 07760186891
dave
October 2007
Automatic Answer
While you wait for answers, we may have found some information which could help you.
howtomendit.com for free repair help, information and advice.
