Leaking Reich mixer tap?

yes,sort of,on my tap there are only two flats on the cartridge retaining nut down inside the swivel housing and i cant see how to get at it. it.any ideas how to. ?

nogginnigel
February 2015

If your tap is a Reich Charisma swivel spout and you have put in a new cartridge, but it still leaks from the bottom of the spout, and the top dome, the problem is the rubber seals (2) at the bottom of the tap where it swivels. When the tap is off, the spout remains full of water and if the seals are faulty, the water seeps out of the joins. The problem is, nobody seems to stock replacement seals!! I've tried everywhere, but no joy. If anyone knows where to buy them, PLEASE let me know!

Dave Cooke
September 2014

Hairline crack in spout weakness in them

mojo
September 2013

Hi,
have the same probelm with my kitchen tap. On taking the tap to bits is the cartridge bit the top bit with the 3 joined rubber rings on the face.
Also is it possible it could be the bottom part of the plastic inset of the tap (the bit theat the red and blue push fit connectors go into. Can't see any damage to either plastic peice. Don't know whether to buy a replacement cartridge just in case its npt that and its actually the bottom bit. Any advice anyone.
Regards
Paul

Paul
May 2011

mine leaking at bottom water coming out where the wires going in this is my second tap with same problem the one i have now is only 6 months old but i have lost the receipt so looks like another £50 00 i think the taps are faulty in manufacture but reich would deny this i am trying to find similar from different manufacture to eliminate it happening again.the moral of the story dont by a caravan with reich taps

hemmo
March 2011

hi.my tap was leaking from underneath too.went to the localshop and bought new seals for in side the tap,underneath ,one on each of the two pipe legs(blue and red)these just pull out.job done total cost less than £1.

RUSSELL 1
July 2010

Just fixed mine so here goes. It was leaking from the top, (frost damage) and Autosleepers advised me to replace the tap. I managed to undo the handle by removing the blue/red plastic grommet and inserting a small allen key. 1st mistake, you don't need to undo the grommet completely. 2nd mistake, you don't need to remove the chrome "sleeve" either. All you need to do is undo the brass nut and remove the cartridge. Total time taken about 3 hours, knowing what I know now, 10 minutes.....

Martyn
January 2010

Similar problem with leak was told the cause was frost damage. I was not convinced so dismantled the tap. Problem caused by damage to flange on the blue and red connectors on the base of the body due to the water pipes being clamped too tight to the wall of the caravan. Solved by rotating the connectors and releasing the clamps on the supply pipes. Really need new connectors to cure the leak as connectors seem to move with vibration or water pressure but can't see spares anywhere. Can anyone help?

IAN NEWSOME
July 2009

hi,
i understand the problem is caused by frost damage.
this year has seen some harsh frosts.
one of the shops I go o has said they have had quite a few occurances of this.

Jase
April 2009

Hi All, Just taken my Shower Tap to bits and found the ceramic in 4 bits! How do i know which size of cartridge to buy. Siin 35mm, 28mm & 40mm. Any help?

Malcolm McNab
March 2009

had same problem remove inlet pipes and check inside body look for tiny black marks these are cracks which allow water to pass from each side passing tap valve not much you can do but replace tap (ouch) £50 plus. p.s. cause supposedly vibration could be as mine started in ireland on back roads

geordie
September 2008

The Reich mixer tap in my caravan was leaking from the top even when the tap was not being used because the water system is pressurised (no microswitch, no wires).
The problem was not due to the rubber seal (3 joined rings - like a face) but to wear inside the cartridge itself.
Got a new cartridge from liesureshopdirect.com (about
£12 incl postage) - problem sorted!
PS. Clean out any scale or other deposits before dropping the new cartridge in - but DON'T use anything that might scratch or score the soft brass housing where the seal sits.
PPS. Don't over tighten the ring nut or you may distort the cartridge. I found that finger tight (hard as you can) then turn one more "flat" with a spanner was enough. If in doubt, under tighten it then gradually tighten until leaking just stops - and then just a LITTLE bit more to make sure.

Bruce Beard
August 2008

Thanks for the advice David. In the end i couldn't get a new cartridge in time. My normal caravan shop didn't stock them -only the taps and they hadn't got the exact one so got one from leisureshopdirect.com in the -best price i could find and delivered really quickly.Went straight in no more messing. We ended up ruining the wire to the micro switch on the old one by the constant unscrewing and trying it. Colin be careful if you undo it all - there are lots of bits inside and the wire is hard to get back in position so the switch sits where it should

Bridget kelly
June 2008

Try taking the cartridge apart and you'll see a 3 ring (bit like a face) rubbere washer on a round plastic disc, also three holes - see if the plastic bit is damaged if so you'll have to buy a new cartridge, otherwise replace the two rubber washers.

David Winter
June 2008

Just discovered the same problem last weekend. Reich Mixer in the bathroom leaking underneath - looks like a constant drip down the middle area of the tap housing. Haven't taken it to bits yet as I was hoping that latest edition of The Caravan Manual might help, but nothing in the book which helps. I think even this edition might be a bit old now ( published 2000, I think ). Hoping I might find out some more this week - our plumber has touring caravan. Have never used this site before, but will try to let you know if I get anywhere.

Colin Robertson
May 2008